Performance Evaluation and Efficiency Enhancement of Water Purification System in a Semi-Recirculated Aquaculture System (RAS)

Document Type : Original Research Article

Authors

Department of Environmental Technologies, Environmental Sciences Research Institute, Shahid Beheshti University, 1983969411, Tehran, Iran

Abstract

 In this study, the status and efficiency of the wastewater treatment system of a semi-recirculated aquaculture system (RAS) in Firoozkooh County were investigated. Information regarding aquaculture systems in the region was obtained with the guidance of the experts at the Agriculture Organization in Firoozkooh County. During visits to the recommended aquaculture systems, Namrud Aquaculture was selected. To evaluate the effect of water pollutants on fish, National Standards 8726 and 7961 were employed to determine water quality parameters and to guide sampling and sample protection. Water quality parameters were assessed at four stations to determine the extent of pollution. The results indicated that ammonia (NH3), nitrite (NO2), and nitrate (NO3) were the main issues in this aquaculture system. Rainbow trout (Oncorhynchus mykiss) exposed to ammonia levels exceeding the limits set by National Standard 8726 displayed behavioral changes, including altered swimming speed, total distance traveled, average direction change, and increased average distance from a central point. The second aeration tower was found to be ineffective in releasing dissolved gases due to its inappropriate design, including the spacing between floors and lack of proper atmospheric connection. It is recommended to redesign the second aeration tower, elevate the second entrance pond, and adjust the return flow to the grit chamber to reduce suspended particles and improve the water quality parameters of the effluent.

Keywords

Main Subjects

References

Ahmed, N. & Turchini, G.M., 2021. Recirculating aquaculture systems (RAS): Environmental solution and climate change adaptation. Journal of Cleaner Production, 297, 126604.
Ali, I., 2012. New generation adsorbents for water treatment. Chemical Reviews, 112, 5073-5091.
Avnimelech, Y. & Kochba, M., 2009. Evaluation of nitrogen uptake and excretion by tilapia in bio floc tanks, using 15N tracing. Aquaculture, 287, 163-168.
Badiola, M., Mendiola, D. & Bostock, J., 2012. Recirculating Aquaculture Systems (RAS) analysis: Main issues on management and future challenges. Aquacultural Engineering, 51, 26-35.
Buentello, J.A., Gatlin III, D.M. & Neill, W.H., 2000. Effects of water temperature and dissolved oxygen on daily feed consumption, feed utilization and growth of channel catfish (Ictalurus punctatus). Aquaculture, 182, 339-352.
Campanati, C., Willer, D., Schubert, J. & Aldridge, D.C., 2022. Sustainable intensification of aquaculture through nutrient recycling and circular economies: more fish, less waste, blue growth. Reviews in Fisheries Science & Aquaculture, 30, 143-169.
Cole, D.W. et al., 2009. Aquaculture: Environmental, toxicological, and health issues. International Journal of Hygiene and Environmental Health, 212, 369-377.
d’Orbcastel, E.R., Blancheton, J.-P. & Aubin, J., 2009. Towards environmentally sustainable aquaculture: Comparison between two trout farming systems using Life Cycle Assessment. Aquacultural Engineering, 40, 113-119.
DeLong, D.P. & Losordo, T.M., 2012. How to start a biofilter.
Emparanza, E.J., 2009. Problems affecting nitrification in commercial RAS with fixed-bed biofilters for salmonids in Chile. Aquacultural Engineering, 41, 91-96.
Francis-Floyd, R., 2020. Dissolved Oxygen for Fish Production: FA27/FA002, rev. 5/1997. EDIS, 2020.
Fu, B., Liao, X., Ding, L. & Ren, H., 2010. Characterization of microbial community in an aerobic moving bed biofilm reactor applied for simultaneous nitrification and denitrification. World Journal of Microbiology and Biotechnology, 26, 1981-1990.
Hagopian, D.S. & Riley, J.G., 1998. A closer look at the bacteriology of nitrification. Aquacultural Engineering, 18, 223-244.
Jobling, M., 1993. Bioenergetics: feed intake and energy partitioning, Fish ecophysiology. Springer, pp. 1-44.
Langone, M. et al., 2014. Coexistence of nitrifying, anammox and denitrifying bacteria in a sequencing batch reactor. Frontiers in Microbiology, 5, 28.
Lu, J., Zhang, Y., Wu, J. & Wang, J., 2020. Nitrogen removal in recirculating aquaculture water with high dissolved oxygen conditions using the simultaneous partial nitrification, anammox and denitrification system. Bioresource Technology, 305, 123037.
Malone, R.F. & Pfeiffer, T.J., 2006. Rating fixed film nitrifying biofilters used in recirculating aquaculture systems. Aquacultural Engineering, 34, 389-402.
Marking, L.L. & Bills, T.D., 1982. Factors affecting the efficiency of clinoptilolite for removing ammonia form water. The Progressive Fish-Culturist, 44, 187-189.
Patel, P., Naik, A. & Sharma, A., 2022. Isolation and identification of nitrite-oxidizing microbes. Practical Handbook on Agricultural Microbiology, 219-221.
Rajta, A., Bhatia, R., Setia, H. & Pathania, P., 2020. Role of heterotrophic aerobic denitrifying bacteria in nitrate removal from wastewater. Journal of Applied Microbiology, 128, 1261-1278.
Summerfelt, S.T., 2006. Design and management of conventional fluidized-sand biofilters. Aquacultural Engineering, 34, 275-302.
Taylor, J.C. & Miller, J.M., 2001. Physiological performance of juvenile southern flounder, Paralichthys lethostigma (Jordan and Gilbert, 1884), in chronic and episodic hypoxia. Journal of Experimental Marine Biology and Ecology, 258, 195-214.
Tomaszewski, M., Cema, G. & Ziembińska-Buczyńska, A., 2017. Significance of pH control in anammox process performance at low temperature. Chemosphere, 185, 439-444.
Van Kessel, M.A. et al., 2015. Complete nitrification by a single microorganism. Nature, 528, 555-559.
Van Rijn, J., 2013. Waste treatment in recirculating aquaculture systems. Aquacultural Engineering, 53, 49-56.
Xu, H. et al., 2022. Nitrification performance and bacterial community dynamics in a membrane bioreactor with elevated ammonia concentration: The combined inhibition effect of salinity, free ammonia and free nitrous acid on nitrification at high ammonia loading rates. Science of the Total Environment, 831, 154972.

Files

Share

How to cite

Statistics